ToyotaTundra2008V8/toyota/tundra/2008/v8/

2008 Toyota Tundra — V8

Factory specifications, fluid capacities, torque values, EPA fuel economy and the federal safety record for the 2008 Tundra V8. Covers both the standard and High Output V8.

Body TRUCKEngine V8

The 2008 Toyota Tundra V8 is a full‑size truck powered by a V8 engine that requires 5.5 qt of 5W‑30 API oil. Owner feedback for this year shows 326 total complaints, with the Vehicle Speed Control system being the most frequently cited issue, and the model was subject to 13 recalls. Looking at the broader Tundra complaint record from 1999 to 2016, the 2008 figure sits well below the 2000 peak of 1,032 complaints but above the 1999 low of just 1 complaint. Consequently, the 2008 model year represents a mid‑range point in the truck’s reliability history, reflecting noticeable improvement over the worst year while still trailing the earliest year’s exceptionally low complaint count.

Model year201120102009200820072006200520042003

Quick specs

Fluid capacities, tune-up values and fuel economy at a glance.

Engine oil capacity5.5 qtOEM · verified
Engine oil type5W-30 APIOEM · verified
Lug nut torque154 ft-lbsOEM · verified

Fitment & sizes

Replacement part sizes and factory part numbers — battery, bulbs, filters and belts.

From the factory this vehicle uses a BCI 24F · 585 CCA battery, OE oil filter 90915YZZD3. Each part links to every other vehicle that shares it, so a part you already stock may fit more of your fleet than you'd expect.

Battery groupBCI 24F · 585 CCAOEM · verified
Tail / brake / turnTAILOEM · verified
Tire sizeP275-70R18OEM · verified
Wheel / rimN/A inOEM · verified

OE service part numbers OEM · verified

Engine oil filter90915YZZD3 alt 9030179006
Engine air filter178010P010 alt 178010S010
Spark plug9091901191 alt 9008091180
Battery28800AA041 alt 2880003044
Front wiper blades852120C030 alt 852220C030
Serpentine belt90916A2001 alt 90916A2033
Thermostat9091603138 alt 1632631050
Cabin air filter8713907010

Full specifications

Engine, drivetrain, dimensions and economy.

Dimensions & weight NHTSA vPIC

Overall length228.7 in
Overall width79.9 in
Overall height76 in
Wheelbase145.7 in
Track (front / rear)67.3 / 67.7 in
Weight distribution (front / rear)58/42

Performance & power Independent road tests

0–60 mph, quarter-mile, horsepower and torque from independent road tests.

Independent published road-test results.

6.0 sec0–60 mph (tested)quickest 6.00 sec — 2008 Limited 5.7L Double Cab (6.6 ft. Bed)
381 hpHorsepower (as tested)
401 lb-ftTorque (as tested)
YearTrim / engine0–60¼ mileHPDrivetrain
2008Limited 5.7L Double Cab (6.6 ft. Bed) 5.7L V86.00 sec14.70 sec381 hp4x4
2007Limited 5.7L Double Cab (6.6 ft. Bed) 5.7L V86.00 sec14.60 sec381 hp4x4
2007Limited 5.7L Double Cab (6.6 ft. Bed) 5.7L V86.10 sec14.90 sec381 hp4x4
2007SR5 5.7L Double Cab (6.6 ft. Bed) 5.7L V86.20 sec14.90 sec381 hp4x4
2009Limited CrewMax Cab (5.6 ft. Bed) 5.7L V86.50 sec15.10 sec381 hp4x4
2010SR5 4.6L Double Cab (6.6 ft. Bed) 4.6L V87.40 sec15.90 sec310 hp4x4
2014Limited CrewMax Cab (5.6 ft. Bed) 5.7L V86.40 sec15.10 sec381 hp4x4
20141794 Edition CrewMax Cab (5.6 ft. Bed) 5.7L V86.70 sec15.20 sec381 hp4x4

Service quick specs OEM factory data

Capacities, torques and tune-up values from the factory service manual.

This engine holds 5.5 qt of 5W-30 API engine oil, 75W-90 · GL-5 in the differential, DOT 3 brake fluid. Torque lug nuts to 154 ft-lbs, the oil drain plug to 30.0 ft-lbs. The firing order is 1-8-4-3-6-5-7-2.

Lubricants & capacities

Brake FluidDOT 3
Differential Gear Oil75W-90 · GL-5
Differential Gear Oil Capacity4.4 Pints
Differential Gear Oil75W-90 · GL-5
Differential Gear Oil Capacity9.8 Pints
Engine Oil5W-30 · API
Engine Oil Capacity5.5 qt
Engine Oil5W-30 · API

Engine torques

Camshaft Bearing/Carrier Cap Bolts or Studs10MM Bolts: 7 ft-lbs, 12MM Bolts: 18 ft-lbs
Crankshaft Pulley and/or Damper Bolts181 ft-lbs
Crankshaft Pulley and/or Damper Bolts221 ft-lbs
Engine Flywheel Bolts61 ft-lbs
Engine Oil Pan Drain Plug30.0 ft-lbs
Engine Oil Pan Drain Plug29.0 ft-lbs
Engine Oil Pan Drain Plug30.0 ft-lbs
Oil Pump to Cylinder BLock Bolts/Studs7 ft-lbs

Chassis torques

Leaf Spring to Axle (U-bolts)74.0 ft-lbs
Leaf Spring to Chassis Bracket77.0 ft-lbs
Leaf Spring to Rear Shackle77.0 ft-lbs
Leaf Spring Rear Shackle to Chassis Bracket77.0 ft-lbs
Lug Nuts154 ft-lbs
Transfer Case Fill Plug27.0 ft-lbs
Transfer Case Drain Plug27.0 ft-lbs
Front Wheel Hub249 ft-lbs

Ignition

Cylinder Firing Order1-8-4-3-6-5-7-2
Curb Idle Speed (No Load)700 rpm
Curb Idle Speed Variance (No Load)50 rpm
Curb Idle Speed (No Load)700 rpm
Curb Idle Speed Variance (No Load)50 rpm
Curb Idle Speed (No Load)700 rpm
Curb Idle Speed Variance (No Load)50 rpm
Ignition Timing8-12, Not adjustable degrees

Battery & A/C

RefrigerantR134a
Refrigerant Capacity1.25-1.38 lbs
Oil GroupPAG
Oil Type46
Oil Capacity4.50 oz
Standard BCI Group Number24F
Standard BCI Cranking Performance585 cca
Optional BCI Group Number27F

Service checks

Pressure Test17 psi
Radiator Cap Pressure Relief14-18 psi
Thermostat Opening Temperature176-183 °F
Pressure Test17 psi
Radiator Cap Pressure Relief14-18 psi
Thermostat Opening Temperature176-183 °F
Fuel Pump Pressure Minimum40.8 psi
Fuel Pump Pressure Maximum41.7 psi

Brakes

Torque Caliper to Bracket25 ft-lbs / 20 ft-lbs
Torque to Knuckle79 ft-lbs / 46 ft-lbs
Minimum Pad ThicknessFront: 0.039; Rear: 0.039 in
Minimum Shoe Thickness0.039 in
Rotor Runout Limit0.0019 in / 0.0078 in
Rotor Nominal Thickness From1.26 in / 0.709 in
Rotor Nominal Thickness To1.26 in / 0.709 in
Rotor Discard at or Under1.142 in / 0.63 in

Multi-step torque procedures OEM · verified

Connecting Rod (Large End) Bearings — tightening sequence 1 stages
118 ft. lbs., Step 2: 9018 ft. lbs
Connecting Rod (Large End) Bearings — tightening sequence 1 stages
118 ft. lbs., Step 2: 9018 ft. lbs
Connecting Rod (Large End) Bearings — tightening sequence 1 stages
130 ft. lbs., Step 2: 9030 ft. lbs
Engine Flywheel Bolts — tightening sequence 1 stages
136 ft. lbs., Step 2: 9036 ft. lbs
Engine Flywheel Bolts — tightening sequence 1 stages
122 ft. lbs., Step 2: 9022 ft. lbs
Main Bearings — tightening sequence 1 stages
120 ft. lbs., Step 2: 9020 ft. lbs

Factory maintenance schedule OEM · verified

Normal service, condensed from the factory interval matrix.

Under the factory schedule, replace the engine oil and filter every 5,000 mi; coolant every 50,000 mi. The big-interval services (every 50,000 mi for coolant, and the transmission fluid) are the ones owners most often skip — on a lower-mileage example, assume the original fluids are still in it and check them first.

Every 5,000 miBrake Linings (inspect) · Engine Oil (drain & refill) · Engine Oil Filter (replace) · Tire & Wheel Assembly (rotate)
At 15,000 miCabin Air Filter (clean)
Every 15,000 miAccessory Drive Belt (inspect) · Air Conditioning Condenser (inspect) · Brake Line (inspect) · CV Joint Boot (inspect) · Differential (inspect fluid level) · Driveshaft (inspect)
Every 30,000 miBrake Rotor (inspect) · Cabin Air Filter (clean) · Cabin Air Filter (replace) · Engine Air Filter Element (replace) · Fuel Evaporative Emission Control System Lines (inspect) · Fuel Line (inspect)
Every 50,000 miEngine Coolant System (drain, flush & refill)
At 60,000 miAccessory Drive Belt (inspect)
Every 60,000 miEngine Valves (inspect valve lash)
Every 90,000 miTiming Belt (replace)
At 100,000 miEngine Coolant System (drain, flush & refill)

Reliability & federal safety record

Owner-reported issues, recalls, investigations and service bulletins on record with NHTSA — an unfiltered look at what owners actually experience.

The 2008 Tundra recorded 326 complaints and 13 recalls, placing it below the 2007 peak of 389 complaints and 14 recalls but above the 2009 low of 38 complaints. Its top complaint categories — Vehicle Speed Control (49), Structure (35), Engine (22), and Power Train (21) — align with earlier years’ recurring issues but do not indicate a new pattern. Crash‑related complaints (24) and fire‑related complaints (2) are modest relative to the broader complaint count. Across the generation, complaint volume generally declined after 2006, and the 2008 figures sit near the upper end of that downward trend, while recalls remained consistent with the 2009 level. Therefore, the 2008 model is acceptable to consider, provided a comprehensive vehicle inspection is performed.

13
Open recalls
NHTSA campaigns
280
Service bulletins
Manufacturer communications
0
ODI investigations
Office of Defects Investigation
326
Owner complaints
24 involved a crash · 2 a fire
NHTSA crash-test rating federal NCAP · out of 5 stars
Rollover★★★★
Owner complaints by model year NHTSA · this generation & adjacent

Owner complaints filed with NHTSA, by component

All 326 complaints on record, top 8 components.

Vehicle Speed Control49
Structure35
Engine22
Power Train21
Unknown Or Other16
Suspension16
Engine & Engine Cooling10
Electrical System9

Source: NHTSA Office of Defects Investigation complaint database.

Recalls NHTSA · verified

Showing 2 of 13 campaigns on record for this vehicle.

21V920000Steering:Hydraulic Power Assist SystemReported 23/11/2021

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2008-2022 Sequoia and 2007-2021 Tundra vehicles. The power steering gear assembly may have been manufactured incorrectly, which can result in an oil… Remedy: Dealers will inspect and replace the power steering gear assembly as necessary, free of charge. Owner notification letters were mailed on January 21, 2022. Owners may contact…

21E103000Steering:Hydraulic Power Assist SystemReported 23/12/2021

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain JTEKT power steering gear assembly service parts for 2007-2021 Tundra and 2008-2022 Sequoia, part numbers 44250-0C160, 44250-0C131, 44250-0C170, and… Remedy: Dealers will inspect and replace the power steering gear assembly, free of charge. Owner notification letters were mailed on February 17, 2022. Owners may contact Toyota customer…

Technical service bulletins NHTSA · verified

Showing 5 of 280 bulletins on record with NHTSA.

BulletinDateComponentSummary
T-SB-0055-24 Rev22026-01-07Unknown Or OtherSome 2005 – 2026 Toyota vehicles that have undergone water intrusion may exhibit a…
T-SB-0035-24 Rev22024-12-06StructureAcid rain results from rainwater or other airborne moisture that become acidic due to…
T-SB-0038-24 Rev22024-12-06StructureTo prevent brake rotor rust from forming during transportation and storage, wheel film…
T-SB-0039-24 Rev22024-12-06StructureThe condition known as acid rain is caused by airborne chemicals or particles in the…
T-SB-0061-23 Rev22024-12-05StructureToyota vehicles are currently protected with RapgardTM protective film designed to…

Common OBD-II trouble codes

The most common OBD-II codes for this vehicle's emissions system. These are standardized SAE J2012 definitions, not vehicle-specific fault reports.

P0420
Catalyst system efficiency below threshold — Bank 1
P0300
Random / multiple cylinder misfire detected
P0171
System too lean — Bank 1
P0455
Evaporative emission system leak detected — large leak
P0128
Coolant thermostat below regulating temperature
P0442
Evaporative emission system leak detected — small leak

VIN tools

Decode factory build data for a specific vehicle by VIN.

VIN
Decode a VIN to confirm the transmission and build data for a specific Tundra. OEM
Build data
Plant, GVWR class, engine and body data for any 17-character VIN.
Recalls
Check open recall campaigns against a specific vehicle by VIN.

Vehicles with shared specs

Find every vehicle that shares this one's battery, bulbs, oil capacity, platform or parts.

Reference guides

Cross-vehicle references for the kinds of data on this page.

Frequently asked

How much oil does the 2008 Tundra V8 take?

5.5 qt of 5W-30 API, per the factory manual.

Does the 2008 Tundra have open recalls?

NHTSA lists 13 recall campaign(s) for this model year. Check your specific vehicle by VIN.